Investigation of the sound absorption properties of gypsum particleboard produced with kenaf stalks and nano clay | ||
| تحقیقات علوم چوب و کاغذ ایران | ||
| Article 9, Volume 29, Fall 3 - Serial Number 48, November 2014, Pages 434-442 PDF (674.97 K) | ||
| Document Type: Research Paper | ||
| DOI: 10.22092/ijwpr.2014.8481 | ||
| Authors | ||
| Hossein Rangavar* 1; Mohammad hassan Payan2 | ||
| 1Assistant Prof., Wood Science and Technology Department, Shahid Rajaee Teacher Training University, Lavizan, Tehran, Iran | ||
| 2M.Sc., Wood Science and Technology Department , Shahid Rajaee Teacher Training University, Lavizan, Tehran, Iran | ||
| Abstract | ||
| In this study sound absorption coefficient and hardness of gypsum particleboard produced with kenaf stalk and nano clay were investigated. Variables in this study were weight ratio of kenaf stalks to poplar wood in three levels (40, 50 and 60 %) and nano clay content (0, 3 and 6%) based on dried mass of wooden particles. Sound absorption coefficient determined according to ISO 10534-1 and hardness was measured in accordance with the ASTM D-1037 standards. The sound absorption coefficient was measured at four frequencies of 250, 500, 1000, and 2000 Hz. The obtained results showed that with increasing frequencies, sound absorption coefficient increased. With increasing ratio of kenaf stalk in boards, hardness decreased, but sound absorption increased. Furthermore, increase in percentage of nano clay used in the boards increased the hardness and reduced the sound absorption in coefficient in gypsum particleboard. Generally, the highest sound absorption coefficient was shown the boards produced with 60% kenaf and without nano clay in frequencies of 2000 Hz. | ||
| Keywords | ||
| Keywords: Sound absorption coefficient; Gypsum particleboard; Nano clay; kenaf stalk; hardness | ||
| References | ||
|
-Abdolzadeh, H., Doosthoseini, K., N. Karimi, A., and. Enayati, A. A., (2010). The Effects of Type of Resin and Acetylation of Poplar Particles on Acoustical Properties and Surface Quality. Journal of Forest and Wood Products (JFWP), Iranian Journal of Natural Resources, Vol. 63, No. 2,151-160. -Charles, L.W., Venita, K.B., and Robert, E.B., 2002. Kenaf harvesting andProcess ing. ASHS Press, Alexandria, VA. -Charles, W., and Bledsoe, V.K., 2001. Kenaf yield components and plantcomposition. National symposium on new crops and new uses.Sunnyville ave, USA. -Dusthoseini, K., and Elyasi, A., 2012. Study on the possibility of using bagasse in manufacture of sound-proof particleboard. Iranian Journal of Wood and Paper Industries, Vol. 3, No. 1, Spring & Summer 2012: 43-52. -Hang – Seung Y., Dac-Junkim, 2003. Rice straw – wood particle composite for sound absorbing wooden construction material, Biere source Technology, 117-121. -Hang-Seung, Y., Dac-Junkim, 2004. Possibility of using waste tire composites reinforced with rice straw a construction materials, Biore source Technology 95(2004). 61-65. -Hang-Seung, Y., Dac-Junkim, 2004. Possibility of using waste tire composites reinforced with rice straw a construction materials, Biore source Technology 95(2004). 61-65. -Joshi, S.V., L.T. Drzal, A.K. Mohanty and S. Arora, 2004. Are natural fiber composites environmentally superior to glass fiber reinforced composites. Composites Part A: Applied Sci. Manufactur., 35: 371-376. DOI:10.1016/j.compositesa.2003.09.016 -Kim, S., Kim, J.A., An, J.Y., Kim, H.S., Kim, H.J., Deng, Y., Feng, Q., Luo, J., 2007 Physico-Mechanical Properties and the TVOC Emission Factor of Gypsum Particleboards Manufactured with PinusMassoniana and Eucalyptus Sp. Macromol Mater Eng 292: 1256-1262. -Lee, J., and Swenson, G.W., 1992. Compact sound absorbers for low frequencies. Noise Control Eng, J., 38: 109-117. -Li, G., Yu, Y., Zhao, Z., Li, J and Li, C., 2003. Properties study of cotton stalk fiber/gypsum composit, Cement and Concrete Research 33: 43 – 46. -Noorbakhsh, A., 1997. The effect of frequency on the absorption coefficient of sound insulation particleboard. Wood and Paper Science Research, number 3, Research Institute of Forests and Rangelands, Page of 230. -Poudinehpour, M., Ebrahimi, Gh.,Tajvidi, M., Charmahali. M., and Ramtin. A., (2006). The effects of two kinds of agricultural wastes (wheat and barely straws) on nrc% of aspen particleboards. Iranian Journal of Wood and Paper Science Research Vol. 21 No. (2), 61-69. -Standard ISO 10534-1: 1996, Acoustics - Determination of sound absorption coefficient andimpedance in impedance tubes – Part1: Method using standing wave ratio -Xue, Y., Du, Y., Elder, S., Devin, S., Horstemeyer, M., and Zhang, J. 2007. Statistical Tensile Properties ofKenaf Fibres and Its Composites, 9International Conference onWood & Biofiber Plastic Composite, 22 May 2007, Mississippi State University, Available online: http://www.forestprod.org/woodfiber07xue.pdf. | ||
|
Statistics Article View: 2,439 PDF Download: 1,614 |
||
Journal management system. designed by sinaweb