The influence of drying conditions on the chemical characteristics of bagasse recycled pulp | ||
| تحقیقات علوم چوب و کاغذ ایران | ||
| Article 2, Volume 29, Summer 2 - Serial Number 47, August 2014, Pages 190-198 PDF (258.57 K) | ||
| Document Type: Research Paper | ||
| DOI: 10.22092/ijwpr.2014.5682 | ||
| Authors | ||
| Mohammad Alishahi1; Omid Ramezani2; Hossein Kermanian* 2; Mehdi Rahmani nia3; Seid Atefeh Nasiri4; Sahar Jalalvand5 | ||
| 1M.Sc., student, Department of Cellulose and Paper, Faculty of New Technologies Engineering. Shahid Beheshti University, Zirab pardis, Savadkooh, Mazandaran, Iran | ||
| 2Assistant Professor, Department of Cellulose and Paper, Faculty of New Technologies Engineering. Shahid Beheshti University, Zirab pardis, Savadkooh, Mazandaran, Iran | ||
| 3Assistant Professor, Wood and Paper Science and Technology Department, Natural Resources Faculty, Tarbiat Modares University, Iran | ||
| 4M.Sc., student, Department of Pulp and Paper, Gorgan University, Golstan, Iran | ||
| 5M.Sc., Student, Department of Cellulose and Paper, Faculty of New Technologies Engineering. Shahid Beheshti University, Zirab pardis, Savadkooh, Mazandaran, Iran | ||
| Abstract | ||
| In this research, the influence of paper drying condition, as one of the most important variable in paper recycling, on the characteristics of fibers was studied. In this respect, bagasse soda pulp was collected from Pars Paper mill in Khozestan province and handsheets were made. The control hand sheet samples were dried at room temperature and the rest of the handsheets were dried using drum dryer set at 60° C for 3 hours, 100° C for 50 minutes and 120° C for 25 minutes to reach the same moisture content as the sheets dried at room temperature. Then, these handsheets were slushed in water and the pulp properties were determined. The results showed that with increasing the drying temperature, cellulose content did not change while hemicelluloses were reduced. Although the assessment of changing the lignin content with micro kappa method showed an increasing trend, but based on previous literature, it was concluded that the result are not justified. Also, the results indicated that changing the degree of polymerization and crystallinity did not show a consistent trend, showing initial reduction following by increased values. These results were attributed to interaction effect of drying temperature and time. | ||
| Keywords | ||
| drying; Bagasse; recycling; chemical composition; crystallinity; degree of polymerization | ||
| References | ||
|
-Atalla, R. H., Ellis, J. D., and Schroeder, L. R., 1984. Some effects of elevatedtemperatures on the structure of cellulose and its transformation. J. Wood Chem.Technol. 4(4), 465-482. -Binod, P., Satyanagalakshmi, K., Sindhu, R., Janu, K. U., Rajeev K. Sukumaran, R. K. and Pandey, A., 2011. Short duration microwave assisted pretreatment enhances the enzymatic saccharification and fermentable sugar yield from sugarcane bagasse. Renewable Energy 37: 109 -116. -Boonstra, M., and Blomberg, J., 2007. Semi-isostatic densification of heat-treated radiation pine. Wood Sci. Technol. 41, 607-617. -Bovin, A., N. Hartler, and A.Teder.,1973. Changes in pulp quality due to repeated papermaking. Paper Tech., 1973. 14(5): p. 261-264. -Campbell, W.B., 1959. The Mechanism of bonding. TAPPI. 42(12): p.999-1001. -Ciolca D, Popa V., 2006. On The Thermal Degradation of Cellulose Allomorphs. Cell chem technol 40(6): 445-449. -Concalves, C., 2001. The eucalyptus fiber for tissue papers. 7th Brazilian symposium on the chemistry of lignin and other wood components. p.317-323. -Dirol D, Guyonnet R., 1993. The improvement of wood durability by retificationprocess. IRG/WP 93-40015, 11 p. -Esteves, B.M., and Pereira, H.M., 2009. Wood modification by heat treatment: a review BioResourse. 4(1), 370-404. -Faezipour, M.M., 2007. paper and agricultural resources of several structures translates. Institute of Tehran University Press, Tehran, first edition, 576. -Hattula, T., 1985. Effect of heat and water on the ultrastructureof wood cellulose, Doctoral Dissertation, The Finnish Pulp and Paper Institute, Helsinki. -Herbst, J. and Douek , M., 1994. The effect of recycling on the chemical properties of pulps , journal of pulp and paper science 20(5): J131. Jayme, G., 1944. Mikro-Quellungsmessungen and Zellstoffen, Der Papier- Fabrikant/Wochenblatt fur Paperfabrikation 6:187. -klungness, J.H, and Caulfield, D.F., 1982. Mechanisms affecting fiber bonding during drying and aging of pulps, TAPPI 65(12): 94 -Laivins, G. V. and A.M. Scallan., 1993. The mechanism of hornifcation of woodpulps. In Products of Papermaking, Tenth Fundamental Research Symposium,(C. F. Baker, ed.) Vol. 2, Oxford. p. 1235-1260. -Lundberg, R. and De Ruvo,A., 1978. “Influence of drying conditions on recovery of swelling and strength of recycled fiber. Sevens Papperstidn, 81(11):355-357. -Nada AMA, Hassan ML., 2000. “Thermal behaviour of celluloseand some cellulose derivatives”. PolymDegrad Stab 67:111–115. -Ragauskas, Art J., 2000. Influence of Hexenuronic Acids on Kraft Bleaching. Overview of Hexenurinic Acids on Pulp Bleaching.vol 1-30. -Stone, J. E., A.M. Scallan, and B. Abrahamson., 1968. Influence of beating on cellwall swelling and internal fibrillation. SvenkPapperstidning. 19(10): p.687-694. -Tjeerdsma, B F, Stevens, M, Militz, H, van Acker, J., 2002. Effect of process conditions on moisture content and decay resistance of hydro-thermally treated wood. Holzforschung und – verwertung, 94-99. -Tze, W.T. and D.J. Gardner., 2001. Swelling of recycled wood pulp fibers: Effect on hydroxyl availability and surface chemistry. Wood and Fiber Science, 33(3): p. 364-376. -Viera, R. G. P., Filho, G. R., Assunção, R. M. N., Meireles, C., Vieira, J. G. and Oliveira, G. S., 2007. Synthesis and characterization of methylcellulose fromsugar cane bagasse cellulose. Carbohydrate Polymers 67: 182–189. -Young, J.K. Rowell., 1997. Paper and Composites from Agro-Based Resource (CRC Lewis, Boca Raton). 464 page. | ||
|
Statistics Article View: 2,697 PDF Download: 1,866 |
||
Journal management system. designed by sinaweb