Morphological characteristics and chemical components of sunflower stalk (Helianthus annus. Var. cheernianka 66) cultivated in Astara | ||
| تحقیقات علوم چوب و کاغذ ایران | ||
| Article 6, Volume 34, Issue 3 - Serial Number 69, November 2019, Pages 372-386 PDF (748.08 K) | ||
| Document Type: Research Paper | ||
| DOI: 10.22092/ijwpr.2019.127139.1562 | ||
| Authors | ||
| Mona Otarod1; Asghar Tabei* 2 | ||
| 1M.Sc., Graduate, Department of Wood and Paper Science and Technology, Astara Branch, Islamic Azad University, Astara, Iran | ||
| 2Scientific member- Islamic Azad University, Astar Branch | ||
| Abstract | ||
| This study was conducted to determine morphological characteristics and chemical components of sunflower stalks (Helianthus annus. Var, cheernianka 66) cultivated in Astara area. After collecting number of stalks, 6 stalks of the same size were selected to determine for morphological characteristics and remaining stalks were used to determine the chemical components. Morphological tests were performed to determine fibers dimensions and biometric coefficients by sampling from 3 heights of stalks (5%, 50% and 75%).Maceration of fibers was done by Franklin method . Measurement of chemical components was performed on the basis of TAPPI standard in 2 modes such with bark and without bark. The total average of fiber length, fiber diameter, lumen diameter and fiber wall thickness were measured for this stalk as 663µm , 29.848 µm, 25.182 µm and 2.336 µm respectively. The total average of slenderness coefficient, flexibility coefficient and Runkel index of fibers were calculated as 22.681, 84.259 and 0.188 respectively. Average percentage of cellulose, lignin, acetone extractives, alcohol extractives, hot water extractives and ash for this stalk were measured as 40.066, 22.758, 3.953, 1.86, 2.186 and 3.208, respectively. The results showed that fibers length increased with increasing of stalk height, but this increasing was not significant. Fibers diameter, lumen diameter and fibers wall thickness decreased with increasing of stalk height, this decreasing was significant for fibers diameter and lumen diameter in the height of 75%, but it was not significant for fibers wall thickness. Also, the results showed that bark has significant effect on all of the chemical components, so that, the stalk with bark has lower cellulose and more lignin, extractives and ash in compare with the stalk without bark. | ||
| Keywords | ||
| "Sunflower stalk"; "fibers dimensions"; "biometric coefficients"; "chemical components"; "agricultural residues" | ||
| References | ||
|
-Afra, E. and Mohammadi, H., 2013. Sorghum bicolor, A New and Valuable Capability of Nonwood lignocellulosic Materials for Pulp and Paper Industry. J. of Wood & Forest Science and Technology, 19 (4): 21-40. (In Persian) -Ahmadi, K., Ebadzadeh, H.R., Abdshah, H., Kazemian, A. and Rafiei, M., 2018. Handbook of Agricultural Statistics: Vol, 1 (Crops). Ministry of Agriculture – Jahad, Center of Information and Communication Technology. 116p. (In Persian) -Ates, S., Deniz, I., Kirci, H., Atik, C. and Okan, O. T., 2015. Comparison of pulping and bleaching behaviors of some agricultural residues. Turkish Journal of Agriculture and Forestry, 39: 144-153. -Bektas, I., Tutus, A. and Eroglu, H., 1999. A study of the stability of Calabrian pine for pulp & paper manufacture. Turk. J. Agric. For., (23):589- 599. -Ebrahimpour Kasmani, J., Samariha, A. and Kiaei, M., 2011. Effects of agricultural residues on biometry, chemical and morphological properties and use in paper making industrial. Middle – east Journal of Scientific Research, 7 (6): 844 – 850. -FAOSTAT. (2013). Food and Agriculture Organization of the United Nations (FAO), Rome, Italy. Available from: http://www.faostat.fao.org/ -Fiber Futures., 2007. Leftover Straw Gets New Life. Available at http://www.sustainablefuture. org/ futurefibers/ solutions.html//Anchor- Leftove-10496 (accessed 12 october 2007) -Franklin, G.L., 1954. Preparation of thin sections of synthetic resins and wood-resin composites, and a new macerating method for wood. Nature (155): 51–59. -Hashemi, S.P. and Hashemi, S.P., 2013. Morphological characteris and chemical components of sunflower stalk (Helianthus annuus L. Record) cultivated in Astara region. Abstracts of the 2th National Conference of New Technologies in the Wood and Paper Industries. Islamic Azad University, Chaloos Branch, 22-23 October:131. (In Persian) -Jahan Latibari, A., Golbabaei, F., Ziadzadeh, A., Farzi, M. and Vazirian, A., 2009. Investigation on size distribution and fiber dimensions of corn stalks. Iranian Journal of Wood and Paper Science Research, 24(1):1-14. (In Persian). -Kamrani, S., Saraian, A.R., Resalati, H. and Ghasemian, A., 2012. Study of variation trends of fiber dimensions in longitudinal direction of Zagros wheat straw in Golestan province for papermaking. Iranian Journal of Wood and Paper Science Research, 27(3):545-555. (In Persian). -Khristova, P., Gabir, S., Bentcheva, S. and Dafalla, S., 1998. Soda-anthraquinone pulping of sunflower stalks. Ind. Crop. Prod. 9, 9e17. -Kilic Pekgozlu, A., Gulsoy, S.K. and Aycicak, y., 2017. Effect of Stem Height on the Fiber Morphology and Chemical Composition of European Black Pine (Pinus nigra Arnold). Journal of bartin faculty of forestry, 19(2):74-81. -Lopez, F., Eugenio, M.E., Diaz, M.J., Nacimiento, S.A., Garcia, M.M. and Jimenez, L., 2005. Soda pulping of sunflower stalks: Influence of process variables on the resulting pulp. J. Ind. Eng.Chem, 11(3):387-394. -Mahdavi, S., Hosseinzadeh, A., Familian, H., Habibi, M. and Fakhrian A., 2002. The comparison of fiber biometry and chemical components of Phragmites australis for papermaking. Wood and Paper Journal, (14):71-109. (In Persian) -Mckean, W.T. and Jacobs, R.S., 1997. Wheat Straw as a Paper Fiber Source. Prepared for Recycling Technology Assistance Partnership. Prepared by The Clean Washington Center. Washington University,p: 55. -Mousavi, S.M.M., Mahdavi, S., Hosseini, S.Z., Resalati, H. and Yosefi, H., 2009. Investigation on Soda-Anthraquinone Pulping of Rapeseed Straw. Iranian Journal of Wood and Paper Science Research, 24(1):69-79 (In Persian) -Parshin, A. and Dezeeuw, C., 1980. Textbook of Wood Technology. 4th edition. McGraw – Hill, New York -Rowell, M.R. and Young, A., 1997. Paper and composites from agro – based Resources. Lewis Publishers/CRC Press, New York. -Rahmanivasokalaei, Y., Mobasser, H.R., Ghanbari Malidare, A., Andarkhor, A. and Dastan, S., 2010 Determination of the best distance and plant density Lakomka sunflower varieties in Mazandaran. Iranian Journal of Research in Crop Science, 7(2): 29-36. -Rangavar, H., Kargarfard, A. and Hoseiny Fard, M.S., 2016. Investigation on effect of cement type on the cement hydration and properties of wood-cement composites manufactured using sunflower stalk (Helianthus annuus). Iranian Journal of Wood and Paper Science Research, 31(2): 336-348 (In Persian). -Rudi, H.R. and Resalati H., 2006. Semi chemical neutral sulphite pulping of sunflower stalk (Helianthus annuus) for making fluting paper. Journal of Agriculture and Natural Resources, 13(2): 173-182. (In Persian) -Safdar, V.R., Hashemi, S.P., Tabei, A. and Hosseinhashemi, S.Kh., 2012. Anatomical, morphological and chemical properties of Tobacco stalk (Nicotiana tabacum L.). Iranian Journal of Wood and Paper Science Research, 27(3):595-509. (In Persian) -Saheb, N.D. and Jog, J.P., 1999. Natural fiber polymer composites. A review, Adv. Polymer. Tech, (18): 351 – 363. -Shiyarkar, I., Tabei, A. and Farajpoor Roodsari, A., 2013. Morphological characteristics and chemical components of two corn varities (704 & oilseed) cultivated in Astara. Iranian journal of wood and paper science research, 28(3):561-582. (In Persian) -Tutus, A., Comlekcioglu, N., Karaman, S. and Hakki Alma, M., 2010. Chemical Composition and Fiber Properties of Crambe orientalisand C. tataria. Int. J. Agric. Biol., 12(2): 286-290. -Uner, B., Kombeci, K. and Akgul., M., 2016. The utilization of tomato stalk in fiber production: NaOH and CaO pulping process. Wood Research Journal, 61(6): 927-936 -Xu, F., Zhong, X.C., Sun, R.C. and Lu, Q., 2006. Anatomy, ultra structure and lignin distribution in cell wall of Caragana Korshinskii. Industrial Crops and Production, (24):186 – 193. | ||
|
Statistics Article View: 1,573 PDF Download: 629 |
||
Journal management system. designed by sinaweb